Models: AQV05 AQV06
Air Conditioner
Owner’s Manual
3
4
Important Safety Information
Operating Instructions
The Controls on Your Air Conditioner
Care of Product
7
Installation Instructions
Important Electrical Safety
Window Installation
12
Helpful Information
Things That Are Normal
13
If Something Goes Wrong
Before You Call for Service
GE Service Numbers
Warranty
GE Answer Center®
800.626.2000
GE Appliances
Important Safety Information
Read all safety information before using
• This air conditioner must be
properly installed in accordance
with the Installation Instructions
before it is used.
• Turn the mode control knob to OFF
and unplug your air conditioner
before making any repairs.
NOTE: We strongly recommend
that any servicing be performed by
a qualified individual.
• Repair or replace immediately
all electric service cords that have
become frayed or otherwise
damaged.
Extension Cord
If an extension cord is required to
reach the nearest wall receptacle,
use only a UL Listed, 3-wire,
grounded, 14 gauge, 15A, 125V
appliance extension cord. For
models with nameplate ratings
greater than 12 amperes, do not
use an extension cord.
Adapter Plug
Because most 2-prong outlets are
not grounded, we strongly advise
against using an adapter plug.
However, a temporary connection
may be made where local codes
permit and if the 2-prong wall out-
let is properly grounded.
FOR PROPER GROUNDING:
1 Screw the adapter to the outlet,
using the outlet cover screw.
2 Ground the outlet through the house
wiring.
When disconnecting the power
cord from the adapter, hold the
adapter close to the outlet while
pulling the plug out. If this is not
done, the grounding connector is
likely to break with repeated use.
When you plug the adapter in,
make sure the larger prong goes
into the larger slot to provide the
proper polarity for the power cord.
This is a temporary method.
UL-listed adapters are avail-
able at most hardware stores.
If the grounding connector breaks,
DO NOT USE the air conditioner
until a proper ground has again
been made.
SAVE THESE INSTRUCTIONS
3
Operating Instructions
TEMP CONTROL
MODE CONTROL
LOW
COOL
The
5
4
MED
COOL
FAN
OFF
6
3
controls
on your
air
HIGH
COOL
7
2
8
1
conditioner
1
2
2
1
Temp Control
Mode Control
The temp control is used to maintain
HIGH COOL, MED COOL and LOW COOL provide
the room temperature. The compressor will
cycle on and off to keep the room at the same
level of comfort. The higher the number
cooling with different fan speeds.
FAN provides air circulation and filtering
without cooling.
selected, the cooler the indoor air will become.
NOTE:
The blower runs as long as the mode control is
not on OFF.
If you move the switch from a cool setting to
OFF or to the FAN setting, wait at least 3 minutes
before switching back to a cool setting.
4
Cooling Descriptions
FOR NORMAL COOLING
FOR MAXIMUM COOLING
FOR QUIETER & NIGHTTIME COOLING
Select MED COOL with the
thermostat at 4.
Select HIGH COOL with the
thermostat at 8.
Select LOW COOL with the
thermostat at 4.
3
3
Air Direction
Fingertip pressure on the louvers adjusts the
air direction up or straight ahead.
5
Operating Instructions
Care & Cleaning
Grille and Case
Turn the air conditioner off and
To clean, use water and a mild
remove the plug from the wall out- detergent. Do not use bleach or
let before cleaning.
abrasives.
Outdoor Coils
The coils on the outdoor side of
the air conditioner should be
checked regularly. If they are
clogged with dirt or soot they may
be professionally steam cleaned, a
service available through your GE
service outlet.
Air Filter
The air filter behind the front
grille should be checked and
cleaned at least every 30 days or
more often if necessary.
The filter can be cleaned with a
vacuum cleaner to remove light
dust or washed in warm, soapy
water. Rinse and let the filter dry
before replacing it. DO NOT expose
the filter to heat or direct sunlight
when drying.
To remove: Gently pull the filter tab
to the right and slide it out.
CAUTION:
DO NOT operate the air conditioner
without a filter because dirt and lint
will clog it and reduce performance.
6
Installation Instructions
Important electrical safety–read carefully
Important Notes
• For personal safety, this air
CAUTION:
conditioner must be properly
grounded.
Installer: Leave these
instructions with the
appliance.
• Do not, under any circumstances,
cut or remove the third (ground)
prong from the power cord.
• It is important to have the wall
outlet and circuit checked by a
qualified electrician if there is any
doubt as to whether a proper
ground exists.
Owner: Keep these
instructions for future
use.
• Do not change the plug on the
power cord of this air conditioner.
• Aluminum house wiring may
present special problems—
consult a qualified electrician.
• Follow National Electrical
Code (NEC) or local codes
and ordinances.
Electrical
The 115-volt models require a
115/120- volt a.c., 60 Hz grounded
outlet protected with a 15-amp
time delay fuse or circuit breaker.
Requirements
Parallel
115V., 15 Amp.
The 3-prong grounding plug
minimizes the possibility of electric
shock hazard. If the wall outlet you
plan to use is only a 2-prong outlet,
it is your responsibility to have it
replaced with a properly grounded
3-prong wall outlet.
7
Installation Instructions
Before you begin
Parts Included
Window sash seal
Bottom window gasket
Foam top window gasket
2 filler panels
Air conditioner
Security brackets (2)
1″ screws (7)
3⁄8″ screws (6)
Tools Needed
• Phillips screwdriver
• Ruler or tape measure
• Knife or scissors
8
Window
Requirements
• These instructions are for a
standard double-hung window.
You will need to modify them for
other types of windows.
15″ min.
5
1
8
4
23 ⁄ ″ to 35 ⁄ ″
• The air conditioner can be
installed without the filler panels
if needed to fit in a narrow open-
ing. See the window opening
dimensions to the right.
(with filler panels)
3
4
19 ⁄ ″ min.
(without filler panels)
Window opening dimensions
are for a standard double-hung
window.
• All supporting parts should be
secured to firm wood, masonry
or metal.
• The electrical outlet must be
within reach of the power cord.
Do not use an extension cord.
Storm Window
Requirements
A storm window frame will not
allow the air conditioner to tilt
WOOD PIECES:
WIDTH: 2″
towards the outside and will keep it LENGTH: Long enough to fit inside
1/2″ higher
Wood
than frame
from draining properly. To adjust
for this, attach a piece of wood to
the stool.
the window frame.
THICKNESS: To determine the
thickness, place a piece of wood on
the stool to make it 1/2″ higher
than the top of the storm window
frame.
Stool
Storm
window
frame
Attach securely with nails or screws.
9
Installation Instructions
Read completely then follow step-by-step
Attach the
Window Sash Seal
1 Cut the window sash seal to the
2 Peel off the backing and attach
proper length.
the seal to the underside of the
window sash.
Install the
Filler Panels
1 Insert the right and left hand
filler panels into the top and
bottom rails.
2 Secure them with six 3/8″ screws,
three on each side.
Install the Air
Conditioner in
the Window
1 Open the window and place the
air conditioner on the stool.
Balance it and close the window
securely behind the top rail. The
unit should be leveled or slightly
tilted to the outside.
2 Slide the filler panels out on
both sides into the sides of the
window jamb.
3 Insert the bottom window gasket
into the space between the win-
dow stool and the bottom of the
air conditioner to seal outside air.
10
Secure the
Air Conditioner
1 Loosen the screws on both sides
of the case. Hang the security
brackets on and attach them to
the case using the same screws.
3 Secure the top rail of the air
conditioner and the top of the
filler panels to the sash using
three 1″ screws.
2 Secure the brackets to the
stool on both sides using
1″ screws.
3 Using two 1″ screws, attach the
filler panels to the sill, one on
each side. Do not overtighten
the screws.
NOTE:
The security brackets and top rail
screws are used to keep the window
from being raised from the outside.
Install the Window
Gasket
1 Cut the foam top window gasket
2 Stuff the foam between the
glass and the window to prevent
air and insects from getting into
the room.
to the window width.
3 If no filler panels are used,
you need to seal between the
window and the air conditioner
with filler.
11
Helpful Information
Things that are normal
Noise
Explanation
You may hear a pinging noise caused by water being picked up
and thrown against the condenser on rainy days or when the
humidity is high. This design feature helps remove moisture
and improve efficiency.
I G
!
P N
"CLICK"
D R I P
You may hear the thermostat click when the compressor cycles
on and off.
Water will collect in the base pan during high humidity or on rainy
days. The water may overflow and drip from the outdoor side
of the unit.
The fan may run even when the compressor is not on.
WHIR!
12
If Something Goes Wrong
Before you call for service
Problem
Possible Causes
What to Do
Air Conditioner
Doesn’t Start
The air conditioner
is unplugged
• Make sure the air conditioner plug is
pushed completely into the outlet.
The fuse is blown/circuit
breaker is tripped
• Check the house fuse/circuit breaker
box and replace fuse or reset the breaker.
Power failure
• Wait 3 minutes to restart the air conditioner.
Air Conditioner Does
Not Cool as it Should
Air flow is restricted
• Make sure there are no curtains, blinds
or furniture blocking the front of the
air conditioner.
The thermostat control may
not be set high enough
• Turn the knob to a higher number.
The highest setting provides maximum
cooling.
The air filter is dirty
• Clean the filter at least every 30 days.
See the Care and Cleaning section.
The room may have been hot
• When the air conditioner is first turned on
you need to allow time for the room to
cool down.
Cold air is escaping
• Check for open furnace floor registers and
cold air returns.
Cooling coils have iced up
• See Freezing Up below.
Air Conditioner
Freezing Up
Ice blocks the air flow
and stops the air conditioner
from cooling the room
• Set the mode control at FAN or
HIGH COOL with the temp at 1 or 2.
13
GE Service Numbers
We’ll be there!
GE Answer Center®
Whatever your question about any And you can call any time. GE
GE major appliance, GE Answer
Center® information service is
available to help. Your call—and
your question—will be answered
promptly and courteously.
Answer Center® service is open
24 hours a day, 7 days a week.
800.626.2000
In-Home Repair Service
A GE consumer service professional Our factory-trained technicians
will provide expert repair service,
scheduled at a time that’s conve-
know your appliance inside and
out—so most repairs can be han-
nient for you. Many GE Consumer dled in just one visit.
Service company-operated loca-
800-GE-CARES
(800-432-2737)
tions offer you service today or
tomorrow, or at your convenience
(7:00 a.m. to 7:00 p.m. weekdays,
9:00 a.m. to 2:00 p.m. Saturdays).
For Customers With
Special Needs
Upon request, GE will provide
Braille controls for a variety of
GE appliances, and a brochure
to assist in planning a barrier-free
kitchen for persons with limited
mobility. To obtain these items,
free of charge, call 800.626.2000.
Consumers with impaired hearing
or speech who have access to a
TDD or a conventional teletype-
writer may call 800-TDD-GEAC
(800-833-4322) to request informa-
tion or service.
800.626.2000
14
Service Contracts
You can have the secure feeling that GE Consumer Service will still
be there after your warranty expires. Purchase a GE contract while your
warranty is still in effect and you’ll receive a substantial discount. With a
multiple-year contract, you’re assured of future service at today’s prices.
800-626-2224
Parts and Accessories
Individuals qualified to service
their own appliances can have
parts or accessories sent directly
to their home. The GE parts system
provides access to over 47,000
parts…and all GE Genuine Renewal
Parts are fully warranted. VISA,
MasterCard and Discover cards
are accepted.
Care and cleaning instructions con-
tained in this manual cover proce-
dures to be performed by any user.
Other servicing generally should be
referred to qualified service person-
nel. Caution must be exercised,
since improper servicing may cause
unsafe operation.
800-626-2002
Further Service
We’re proud of our service and
Finally, if your problem is still
want you to be pleased. If for some not resolved, write:
reason you are not happy with the
Major Appliance Consumer
Action Program
20 North Wacker Drive
Chicago, IL 60606
service you receive, here are three
steps to follow for further help.
First, contact the people who ser-
viced your appliance. Explain why
you are not pleased. In most cases,
this will solve the problem.
Next, if you are still not pleased,
write all the details—including
your phone number—to:
Manager, Consumer Relations
GE Appliances, Appliance Park
Louisville, KY 40225
15
AIR
CONDITIONER
WARRANTY
Staple sales slip or cancelled check here. Proof of original purchase
date is needed to obtain service under warranty.
What is Covered
FULL ONE-YEAR WARRANTY
**********************************
For one year from date of original pur-
chase, we will provide, free of charge,
parts and service labor in your home to
repair or replace any part of the room air
conditioner that fails because of a manu-
facturing defect.
This warranty is extended to the origi-
nal purchaser and any succeeding
owner for products purchased for use
in the 48 mainland states, Hawaii and
Washington, D.C. In Alaska the warranty
is the same except that it is LIMITED
because you must pay to ship the prod-
uct to the service shop or for the service
technician’s travel costs to your home.
FULL FIVE-YEAR WARRANTY
For five years from the date of original
purchase, we will provide, free of charge,
parts and service labor in your home to
repair or replace any part of the sealed refrig-
erating system (the compressor, condenser,
evaporator and all connecting tubing)
that fails because of a manufacturing
defect.
All warranty service will be provided by
our Factory Service Centers or by our
authorized Customer Care servicers
®
during normal working hours.
Should your appliance need service,
during warranty period or beyond,
call 800-GE-CARES (800-432-2737).
What is Not
Covered
• Service trips to your home to teach
• Replacement of house fuses or reset-
you how to use the product.
ting of circuit breakers.
Read your Owner’s Manual. If you then • In commercial locations labor neces-
have any questions about operating the
product, please contact your dealer or
our Consumer Affairs office at the
address below, or call, toll free:
sary to move the unit to a location
where it is accessible for service by an
individual technician.
• Failure of the product resulting from
modifications to the product or due
to unreasonable use including failure
to provide reasonable and necessary
maintenance.
Failure due to corrosion on models not
corrosion-protected.
Damage to product caused by improp-
er power supply voltage, accident, fire,
floods or acts of God.
GE Answer Center®
800.626.2000
consumer information service
• Improper installation.
•
If you have an installation problem, or
if the air conditioner is of improper
cooling capacity for the intended use,
contact your dealer or installer. You are
responsible for providing adequate elec-
trical connecting facilities.
•
WARRANTOR IS NOT RESPONSIBLE FOR CONSEQUENTIAL DAMAGES.
Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation
or exclusion may not apply to you. This warranty gives you specific legal rights, and you may also have other rights
which vary from state to state. To know what your legal rights are in your state, consult your local or state consumer
affairs office or your state’s Attorney General.
Warrantor: General Electric Company If further help is needed concerning this warranty, write:
Manager—Consumer Affairs, GE Appliances, Louisville, KY 40225
Pub. No. 49-7351
AQV05 AQV06
10-96 CG
Printed in Thailand
|